07.5-21 Dodge Ram 6.7L Cummins 68RFE ATS Co-Pilot Tow Edition Transmission Controller Kit
$795.00
- Part Number: 6019002326
- Est. Ship Time: Usually Ships By Next Business Day

SSL SECURE
TRANSACTION

AUTHENTIC
PRODUCTS

GUARANTEED PREMIUM
QUALITY

A+ Rating
More from this brand
Starting From $2,421.05
Starting From $793.00
Starting From $317.13
ATS 68RFE Tow Edition Co-Pilot Transmission Controller Kit
Fitment: 2007.5-Current Dodge RAM 6.7L Cummins
Fitment: 2007.5-Current Dodge RAM 6.7L Cummins
The 68-RFE is plagued by small clutch packs, weak hard parts, constant slip torque converter lock-up, and inadequate line pressure. Typically, these issues can result in the failure of the stock transmission with only a mild tune or heavy trailer. The Co-Pilot® Tow Edition addresses these concerns.
The Co-Pilot consists of a controller, harness and secondary electronics box. The harness plugs into the main transmission connector on the valve body and is completely plug and play for easy installation. The controller mounts in the cab, and allows the driver to view critical transmission and engine inputs such as line pressure, and both commanded and actual engine load. Viewing the different sensor inputs is as easy as pressing the up or down arrows. These changes can be made on-the-fly or with the vehicle stopped. The secondary electronics box is mounted to the drivers side frame and requires no cutting or fitting.
The Co-Pilot controls line pressure, clutch timing and more aggressively applies the converter clutch under high torque situations. Line pressure is limited in a stock 68-RFE to 160 PSI. Unfortunately, this is not nearly enough to reliably prevent clutch slippage above 400hp. The Co-Pilot reads boost pressure and throttle position to quickly take control of line pressure when it is needed. However, when the vehicle is driven lightly, line pressure is near stock for comfortable shifts. This is all done automatically in the controller. Line pressure is increased dramatically with the addition of an ATS Valve Body Full Pressure Enable Kit. This kit is already installed on any 68-RFE transmission built in-house at ATS, and can also be installed on a stock transmission to safely allow line pressure to increase up to 270 PSI. While the installation of the kit isn't necessary, it will increase the performance of the Co-Pilot to its fullest potential. We recommend installing one of our modified valve bodies to fully address all of the internal hydraulic issues with the 68-RFE valve body.
The Co-Pilot has a huge advantage over TCM programing on 2013 and newer trucks because of the way the factory TCM is designed. When the higher line pressure modifications are done to the valve body on a 2013+ truck, aftermarket TCM tuning that is used will cause a radical pressure variation that spikes line pressure causing many problems. For this reason you will find TCM tuning is less desirable on these newer trucks. When TCM tuning is used, the tuners do not allow for full line pressure increases. The ATS Co-Pilot, utilizing its dynamic closed loop control addresses this with an averaging circuit that provides a very smooth and controllable line pressure rise up to 270PSI. Clutch timing is programmed into the Co-Pilot and crucial to clutch pack life. On any 68-RFE transmission, clutch timing is optimized to reduce wear on clutch packs, efficiently transfer power and increase reliability. The torque converter lock-up apply on a stock 68-RFE leaves a lot to be desired. The factory TCM will command lock-up at a very low speed when at light throttle, this causes a sluggish condition, low boost and poor drivability. The ATS 68RFE Co-Pilot will more firmly lock the converter clutch during apply, this allows the inherent torque of the Cummins engine to be used for improved efficiency and performance.
Modes Available in Co-Pilot:
The Co-Pilot consists of a controller, harness and secondary electronics box. The harness plugs into the main transmission connector on the valve body and is completely plug and play for easy installation. The controller mounts in the cab, and allows the driver to view critical transmission and engine inputs such as line pressure, and both commanded and actual engine load. Viewing the different sensor inputs is as easy as pressing the up or down arrows. These changes can be made on-the-fly or with the vehicle stopped. The secondary electronics box is mounted to the drivers side frame and requires no cutting or fitting.
The Co-Pilot controls line pressure, clutch timing and more aggressively applies the converter clutch under high torque situations. Line pressure is limited in a stock 68-RFE to 160 PSI. Unfortunately, this is not nearly enough to reliably prevent clutch slippage above 400hp. The Co-Pilot reads boost pressure and throttle position to quickly take control of line pressure when it is needed. However, when the vehicle is driven lightly, line pressure is near stock for comfortable shifts. This is all done automatically in the controller. Line pressure is increased dramatically with the addition of an ATS Valve Body Full Pressure Enable Kit. This kit is already installed on any 68-RFE transmission built in-house at ATS, and can also be installed on a stock transmission to safely allow line pressure to increase up to 270 PSI. While the installation of the kit isn't necessary, it will increase the performance of the Co-Pilot to its fullest potential. We recommend installing one of our modified valve bodies to fully address all of the internal hydraulic issues with the 68-RFE valve body.
The Co-Pilot has a huge advantage over TCM programing on 2013 and newer trucks because of the way the factory TCM is designed. When the higher line pressure modifications are done to the valve body on a 2013+ truck, aftermarket TCM tuning that is used will cause a radical pressure variation that spikes line pressure causing many problems. For this reason you will find TCM tuning is less desirable on these newer trucks. When TCM tuning is used, the tuners do not allow for full line pressure increases. The ATS Co-Pilot, utilizing its dynamic closed loop control addresses this with an averaging circuit that provides a very smooth and controllable line pressure rise up to 270PSI. Clutch timing is programmed into the Co-Pilot and crucial to clutch pack life. On any 68-RFE transmission, clutch timing is optimized to reduce wear on clutch packs, efficiently transfer power and increase reliability. The torque converter lock-up apply on a stock 68-RFE leaves a lot to be desired. The factory TCM will command lock-up at a very low speed when at light throttle, this causes a sluggish condition, low boost and poor drivability. The ATS 68RFE Co-Pilot will more firmly lock the converter clutch during apply, this allows the inherent torque of the Cummins engine to be used for improved efficiency and performance.
Modes Available in Co-Pilot:
- Setting 1 (down or all the way to the right) This mode shows you TPS position. No lights = 0% and 5 lights = 100%
- Setting 2 (one position from far right) This mode shows you what the boost sensor sees. No Lights = 0 PSI boost and 5 lights = 40 PSI boost
- Setting 3 (two positions from the right) This mode shows you actual transmission line pressure. No lights = 100 PSI line pressure and 5 lights = 260 PSI line pressure.
ATS: 6019002326

Tags:
ATS Diesel Performance
, ATS
, Co-Pilot
, Co-Pilot Transmission Controller Kit
, Co-Pilot Tow Edition Transmission Controller Kit
ATS Aurora AFR 3000 Aftermarket Factory Replacement TurbochargerFitment: 2001-2004 GM 6.6L DuramaxPart Number: 2023024248If you want a turbo that..
$2,421.05
ATS BoostFooler Electronic Fuel Regulator
Fitment: 2001-2010 GM 6.6L Duramax
The BoostFooler Electronic Fuel Regulator will allow..
$69.76
Fits: 2001-2010 6.6L Duramax LB7/LLY/LBZ/LMMThis billet steel input shaft is made to fix a weak link in your GM Duramax truck with Allison transm..
$793.00
-Arc Flow Intake, 2003-2005 Dodge Common Rail 5.9L, Cummins, Pre tapped for Gauges and water injection, Includes Powder Coating and Machining. The ATS..
$317.13
2003-2007 Dodge 5.9L Common Rail Cummins, 2-Piece Exhaust Manifold, T3, NON-Wastegated, Comes Assembled with Black High Temperature Coating and Pre-T..
$594.99
ATS Pulse Flow Exhaust Manifold Kit Fits 2003-2007 5.9L Cummins 2-Pc T3 With Gaskets Premium Hardware
Since ATS released the first Pulse Flow Manif..
$694.99
ATS Pulse Flow Exhaust Manifold Kit Fits 2003-2007 5.9L Cummins 2-Pc T3 With Turbo Flange Hardware
Since ATS released the first Pulse Flow Manifold..
$549.99
ATS Fuel Rail Pressure PlugFitment: 2003-07 Dodge 5.9L CRA common failure of the Ram 5.9L Common Rail Cummins is the pressure relief valve. These reli..
$30.00
Fits:
2003-2007 Dodge 5.9L Cummins
This ATS 2049202272 Pulse Flow Exhaust Manifold is the perfect component for your truck! This Manifold ..
$594.99
Fits: 2003-2019 Dodge 2500/3500 (Equipped With 11.5 AAM Differential)2.5 quart fluid capacity over stockOptimal gear lubricationEasy fluid service wit..
$280.68
Fits: 2004.5-2007 5.9L Cummins
Features:
Progressive line rise
Allows 1st-2nd gear lock-up
Optimized to work with 3000 rpm governor spring..
$685.13
ATS Fuel Rail Pressure PlugFitment: 2004½-2010 GM 6.6L Duramax (LLY, LLY/LBZ, LLM) A common failure of the GM LLY, LLY/LBZ, LLM 6.6L Duramax..
$30.00
ATS Aurora VFR 3000 Stage 1 TurbochargerFitment: 2004.5-2010 GM 6.6L DuramaxPart Number: 2023024290If you want a turbo that has a clean install, ..
$2,249.00
ATS Aurora VFR 4000 Stage 2 TurbochargerFitment: 2004.5-2010 GM 6.6L DuramaxPart Number: 2024024290If you want a turbo that has a clean install, ..
$2,631.58
ATS protector/ front diff cover for 05-16 Ford Super Duty trucks with Dana 60's.ATS: 4029011000..
$280.68
Please note: A 20% cancellation fee will be charged for canceled Randy's Transmission items after purchase. If lead time is a concern, please contact ..
$825.00
This G56 transmission case features an updated design that is thicker and reinforced in critical areas. It is intended to back popular 5.9L- and 6.7L ..
$2,336.25
Discontinued (Updated 6/12/25)
Replacement case for the G56 6 Speed Manual transmission. This is an aftermarket replacement case manufactured by US..
$0.00
G56-OR-HD 13" Full HD Performance Organic clutch Rep Set w/o flywheel425 hp 900 trq 20k towing capacity.Does not work on factory flywheel.Upgraded Hyd..
$679.34
G56-OFER ---- 13" half Organic half Feramic clutch kit w/o flywheel 475 hp 1000 trq 25k towing capacity Not recommended for stock applications. Does n..
$849.18
Many years back we (circa 2014) RevMax began using billet valve bodies in their 68RFE 1000 series transmissions. These units featured on demand lockup..
$425.00
Are you tired of your 68rfe not holding power? Do you hate the 20 times it shifts and locks and unlocks while trying to get up to 55mph? Looking to ge..
$2,290.79
Please note: A 20% cancellation fee will be charged for canceled Randy's Transmission items after purchase. If lead time is a concern, please contact ..
$825.00
Please note: A 20% cancellation fee will be charged for canceled Randy's Transmission items after purchase. If lead time is a concern, please contact ..
$1,550.00
The Firepunk FPC1 Competition Stage 1 Transmission for your 00-02 Dodge 5.9L Cummins is the perfect option for the serious performance enthu..
Starting From $6,700.00
The Firepunk FPC2 Competition Stage 2 Transmission for your 00-02 Dodge 5.9L Cummins is a full billet build. This is a 1000HP capable transm..
Starting From $7,850.00
The Firepunk FPC3 Competition Stage 3 Transmission for your 00-02 Dodge 5.9L Cummins is for the ultimate street truck making big power. Suit..
Starting From $9,450.00
The Firepunk FPST Street & Track Transmission for your 00-02 Dodge 5.9L Cummins is perfect transmission package for those who use their ..
Starting From $5,750.00
The Firepunk FPTMP Towmaster Plus Transmission for your 00-02 Dodge 5.9L Cummins is designed for the diesel owner who enjoys the added horse..
Starting From $4,350.00
1947-O-HD ---- 13" Full Organic clutch kit w/o flywheel 425 hp 900 trq 20k towing capacity.Works on factory flywheel.Stage: 2Use: HD-OFt-Lbs: 425hp, 9..
$679.34