07.5-21 Dodge Ram 6.7L Cummins 68RFE ATS Co-Pilot Tow Edition Transmission Controller Kit
- Part Number: 6019002326
- Est. Ship Time: Usually Ships By Next Business Day
$795.00
More from this brand
Starting From $210.00
Starting From $30.00
Starting From $30.00
ATS 68RFE Tow Edition Co-Pilot Transmission Controller Kit
Fitment: 2007.5-Current Dodge RAM 6.7L Cummins
Fitment: 2007.5-Current Dodge RAM 6.7L Cummins
The 68-RFE is plagued by small clutch packs, weak hard parts, constant slip torque converter lock-up, and inadequate line pressure. Typically, these issues can result in the failure of the stock transmission with only a mild tune or heavy trailer. The Co-Pilot® Tow Edition addresses these concerns.
The Co-Pilot consists of a controller, harness and secondary electronics box. The harness plugs into the main transmission connector on the valve body and is completely plug and play for easy installation. The controller mounts in the cab, and allows the driver to view critical transmission and engine inputs such as line pressure, and both commanded and actual engine load. Viewing the different sensor inputs is as easy as pressing the up or down arrows. These changes can be made on-the-fly or with the vehicle stopped. The secondary electronics box is mounted to the drivers side frame and requires no cutting or fitting.
The Co-Pilot controls line pressure, clutch timing and more aggressively applies the converter clutch under high torque situations. Line pressure is limited in a stock 68-RFE to 160 PSI. Unfortunately, this is not nearly enough to reliably prevent clutch slippage above 400hp. The Co-Pilot reads boost pressure and throttle position to quickly take control of line pressure when it is needed. However, when the vehicle is driven lightly, line pressure is near stock for comfortable shifts. This is all done automatically in the controller. Line pressure is increased dramatically with the addition of an ATS Valve Body Full Pressure Enable Kit. This kit is already installed on any 68-RFE transmission built in-house at ATS, and can also be installed on a stock transmission to safely allow line pressure to increase up to 270 PSI. While the installation of the kit isn't necessary, it will increase the performance of the Co-Pilot to its fullest potential. We recommend installing one of our modified valve bodies to fully address all of the internal hydraulic issues with the 68-RFE valve body.
The Co-Pilot has a huge advantage over TCM programing on 2013 and newer trucks because of the way the factory TCM is designed. When the higher line pressure modifications are done to the valve body on a 2013+ truck, aftermarket TCM tuning that is used will cause a radical pressure variation that spikes line pressure causing many problems. For this reason you will find TCM tuning is less desirable on these newer trucks. When TCM tuning is used, the tuners do not allow for full line pressure increases. The ATS Co-Pilot, utilizing its dynamic closed loop control addresses this with an averaging circuit that provides a very smooth and controllable line pressure rise up to 270PSI. Clutch timing is programmed into the Co-Pilot and crucial to clutch pack life. On any 68-RFE transmission, clutch timing is optimized to reduce wear on clutch packs, efficiently transfer power and increase reliability. The torque converter lock-up apply on a stock 68-RFE leaves a lot to be desired. The factory TCM will command lock-up at a very low speed when at light throttle, this causes a sluggish condition, low boost and poor drivability. The ATS 68RFE Co-Pilot will more firmly lock the converter clutch during apply, this allows the inherent torque of the Cummins engine to be used for improved efficiency and performance.
Modes Available in Co-Pilot:
The Co-Pilot consists of a controller, harness and secondary electronics box. The harness plugs into the main transmission connector on the valve body and is completely plug and play for easy installation. The controller mounts in the cab, and allows the driver to view critical transmission and engine inputs such as line pressure, and both commanded and actual engine load. Viewing the different sensor inputs is as easy as pressing the up or down arrows. These changes can be made on-the-fly or with the vehicle stopped. The secondary electronics box is mounted to the drivers side frame and requires no cutting or fitting.
The Co-Pilot controls line pressure, clutch timing and more aggressively applies the converter clutch under high torque situations. Line pressure is limited in a stock 68-RFE to 160 PSI. Unfortunately, this is not nearly enough to reliably prevent clutch slippage above 400hp. The Co-Pilot reads boost pressure and throttle position to quickly take control of line pressure when it is needed. However, when the vehicle is driven lightly, line pressure is near stock for comfortable shifts. This is all done automatically in the controller. Line pressure is increased dramatically with the addition of an ATS Valve Body Full Pressure Enable Kit. This kit is already installed on any 68-RFE transmission built in-house at ATS, and can also be installed on a stock transmission to safely allow line pressure to increase up to 270 PSI. While the installation of the kit isn't necessary, it will increase the performance of the Co-Pilot to its fullest potential. We recommend installing one of our modified valve bodies to fully address all of the internal hydraulic issues with the 68-RFE valve body.
The Co-Pilot has a huge advantage over TCM programing on 2013 and newer trucks because of the way the factory TCM is designed. When the higher line pressure modifications are done to the valve body on a 2013+ truck, aftermarket TCM tuning that is used will cause a radical pressure variation that spikes line pressure causing many problems. For this reason you will find TCM tuning is less desirable on these newer trucks. When TCM tuning is used, the tuners do not allow for full line pressure increases. The ATS Co-Pilot, utilizing its dynamic closed loop control addresses this with an averaging circuit that provides a very smooth and controllable line pressure rise up to 270PSI. Clutch timing is programmed into the Co-Pilot and crucial to clutch pack life. On any 68-RFE transmission, clutch timing is optimized to reduce wear on clutch packs, efficiently transfer power and increase reliability. The torque converter lock-up apply on a stock 68-RFE leaves a lot to be desired. The factory TCM will command lock-up at a very low speed when at light throttle, this causes a sluggish condition, low boost and poor drivability. The ATS 68RFE Co-Pilot will more firmly lock the converter clutch during apply, this allows the inherent torque of the Cummins engine to be used for improved efficiency and performance.
Modes Available in Co-Pilot:
- Setting 1 (down or all the way to the right) This mode shows you TPS position. No lights = 0% and 5 lights = 100%
- Setting 2 (one position from far right) This mode shows you what the boost sensor sees. No Lights = 0 PSI boost and 5 lights = 40 PSI boost
- Setting 3 (two positions from the right) This mode shows you actual transmission line pressure. No lights = 100 PSI line pressure and 5 lights = 260 PSI line pressure.
ATS: 6019002326

Tags:
ATS Diesel Performance
, ATS
, Co-Pilot
, Co-Pilot Transmission Controller Kit
, Co-Pilot Tow Edition Transmission Controller Kit
ATS BoostFooler Electronic Fuel RegulatorFitment: 2001-2010 GM 6.6L DuramaxThe BoostFooler Electronic Fuel Regulator will allow you to utilize yo..
$69.76
The GM Twin Fueler Electronic Control Box controls your second high pressure fuel pump, allowing precise rail pressure control with the Twin Fueler Fu..
$210.00
ATS Fuel Rail Pressure PlugFitment: 2003-07 Dodge 5.9L CRA common failure of the Ram 5.9L Common Rail Cummins is the pressure relief valve. These reli..
$30.00
ATS Fuel Rail Pressure PlugFitment: 2004½-2010 GM 6.6L Duramax (LLY, LLY/LBZ, LLM) A common failure of the GM LLY, LLY/LBZ, LLM 6.6L Duramax..
$30.00
ATS protector/ front diff cover for 05-16 Ford Super Duty trucks with Dana 60's.ATS: 4029011000..
$280.68
The ATS Aurora VFR 4000 Stage 2 Turbocharger AssemblyFitment: 2007.5-2012 RAM 6.7L CumminsThis Aurora VFR 4000 is a direct drop in full emissions lega..
$3,978.10
ATS created this 68RFE transmission case brace to eliminates cracking that can happen when hauling large loads, towing heavy, and working your Dodge 6..
$195.00
Filter Coupler, Billet Aluminum (replaces factory plastic coupler to allow installer to properly tighten the filter) Must use 1/2" Hex Head to install..
$35.53
ATS 68RFE Reinforced Overdrive Clutch HubFitment: 2007½-2022 Dodge RAM 6.7L CumminsBuild your 68RFE like a pro with the ATS Reinforced Overdrive ..
$250.00
ATS Fuel Rail Pressure PlugFitment: 2007½-2018 Dodge Ram 6.7L Cummins Common Rail A common failure of the Ram 6.7L Cummins Common Rail is the pre..
$30.00
ATS PulseFlow 2pc Exhaust Manifold Kit Factory Holset Flange, EGR Compliant, Black CeramicFitment: 2007½-2018 Dodge 6.7L Cummins Common RailFeatures:I..
$650.00
ATS 68RFE Accumulator Piston Set and Accumulator Cover KitFitment: 2007½-current Ram 6.7L CumminsATS: 3031212326..
$120.53
ATS BilletProof 68RFE Billet Pump Plate (plate only)Fitment: 2007½-current Dodge Ram 6.7L Cummins The heart of the 68-RFE transmission is the pum..
$450.00
Fits: 2007.5-2022 Dodge 6.7L Cummins If you own a Ram truck, chances are you have received a TSB from FCA/Stellantis regarding the risk of fire d..
$132.85
ATS BoostFooler Electronic Fuel RegulatorFitment: 2007½-current Ram 6.7L CumminsThe BoostFooler Electronic Fuel Regulator will allow you to ..
$69.76
Fits: 2003-2008 Dodge 5.9L/6.7L CumminsMount your Edge Products CS2 or CTS2 in your 2003-2008 Dodge 5.9L/6.7L Cummins with the Edge Products 38406 CS2..
$116.95
Introducing the next generation Evolution CTS3: all-new,
full-Color Touch Screen CTS3. The CTS3 will continue to include all of the
great features, ..
$730.95
Performance tune your 2003-2012 Dodge 5.9L/6.7L Cummins and
monitor vital engine parameters with the Superchips 3050 Dashpaq In-Cab Tuner.
This slee..
$642.95
Backordered with No ETA **Updated on 05/16/2023**The Superchips 30501
Dashpaq+ In-Cab Tuner For Cummins will give you more horsepower whi..
$649.95
The Superchips 3545 Dodge Ram
FlashCal For Truck Calibration Tool is the perfect device for any truck
enthusiast. The Flashcal For Truck Calibration..
$238.95
It's back! Wake up your 2004.5-2012 Dodge 5.9L/6.7L Cummins with the Diablosport 7303 Predator 2 Programmer. Just like the original, the Predator 2 pr..
$403.95
Fits: 2006-2009 Ram 2500/3500 2006-2008 Ram 1500We are happy to announce all-new cast aluminum pillar display mounts available for order now to offer ..
$52.45
Now there is an easy way to mount your EZ-Lynk shift on the fly switch. Introducing the 5-Position Switch Mount. This mount bolts directly to the bott..
$19.99
When your vehicle’s throttle isn’t what you need, it’s time for a boost with the Bully Dog Thruster. This device is easy to install inline between you..
$299.00
Provide your 2011-2019
F-250 - F-550 Super Duty with superior throttle control with the Hypertech
101300 REACT Performance Throttle Optimizer. The R..
$329.00
Overview
Take
your throttle sensitivity adjustment wireless! The Ampd 2.0 throttle
sensitivity booster is the most advanced throttle modification..
$281.95
OverviewAN ALL
NEW LOOK, AN ALL NEW ATTITUDE! INTRODUCING THE JUICE WITH ATTITUDE CTS3 LINE
AVAILABLE NOW! Featuring our state-of-the-art CTS3 techn..
$1,102.95
ATS BoostFooler Electronic Fuel RegulatorFitment: 2007½-current Ram 6.7L CumminsThe BoostFooler Electronic Fuel Regulator will allow you to ..
$69.76
Fits: 2008+ OBDII VehiclesAdd-On Gauge. Requires any Primary iDash DataMonster or SuperGauge for vehicle communication. Y-cable is included for connec..
$269.00
Fits: 2008+ OBDII VehiclesVehicle Monitoring like no other! — Banks iDash opens a window into the vital inner workings of your vehicle, letting ..
$295.00